Product ID:GLOSS POLY, 6409 SERIES
MSDS Date:08/07/1991
FSC:8010
NIIN:00N053922
MSDS Number: BVVYY

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SO EL MONTE, CA 91733
US

Emergency Phone: 818-444-9274

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

2.1 @ 68F.

CAS: 110-43-0

RTECS: MJ5075000

Fraction By Weight: 15%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM

ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (SARA III).

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM/200STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

70.0

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 2%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM/300STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

3.30 LB/GL (396

RTECS: 9999999VO

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL:HDCH, FATG, WEARINESS,
NAUS, VOMIT, DIZZ, STUPER, DROW, DISTURBED VISION, COUGHING, AND
UNCONSCIOUSNESS. SKIN:PRLNGD CONT CAN CAUSE MOD IRRIT, DEFATTING
AND DERM & TINGLING SENSATION. EYES :CAN CAUSE SEV IRRIT, REDNESS,
TEARING,AND BLURRED VISION. SKIN ABSORP:MOD IRRIT, DEFAT, DERM, DRY
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:SKIN, RASH. INGEST:BREATH SMELLS OF
SOLV, IRRIT OF LIPS & MOUTH, GI IRRIT, NAUS, DIARR, DROW, LOSS OF
CONSCIOUSNESS. STATE OF SHOCK, WEAK & RAPID PULSE, COLD-PALE
COMPLEXION. CHRONIC:MAY PRO DUCE LIVER & KIDNEY DAMAGE, PERSISTANT
COUGHING, BRAIN DAMAGE AND MAY EVEN CAUSE DEATH.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER AND KIDNEY
DISORDERS.

First Aid:EYES:FLUSH W/PLENTY OF WATER FOR 15 TO 30 MINS. GET MED ATTN.
SKIN:WASH EXPOSED ARA W/MILD SOAP & WATE FOR 15 MINS. REMOVE
CONTAMD CLTHG. INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMIN
OXYG. IF B RTHG HAS STOPPED, GIVE ARTF RESP, GET MED ATTN.
INGEST:DO NOT INDUCE VOMIT. KEEP VICTIM WARM & SEEK IMMEDIATE
MEDICAL ATTENTION.

Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:1.1%
Upper Limits:11.4%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA W/FULL FACEPIECE
OPERATED IN PRESSURE DEMAND OR OTHER POSITIVE MODES.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPARKS, ELEC EQUIP & OPEN FLAME. CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT. DURING EMER CNDTNS, (SUPDAT)

Spill Release Procedures:FOLLOW ALL INSTRUCTIONS TO PVNT HLTH HAZ.
ELIMINATE ALL SOURCES OF IGNITION. ABSORB LIQUIDS IN ABSORBANT
MATERIAL & PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CNTNRS MAY BE HAZ WHEN EMPTIED, SINCE
EMPTIED CNTNRS MAY RETAIN PROD RESIDUALS (VAP, LIQ, AND/OR SOLIDS)
ALL PRECAUT GIVE MUST BE OBSERVED.
Other Precautions:STORE @ ROOM TEMP AWAY FROM HEAT SOURCES & HAVE LIDS
TIGHTLY CLSD. OVEREXPOS HAS APPARENTLY BEEN FOUND TO CAUSE
FOLLOWING EFTS IN LAB ANIMALS:LIVER ABNORM, KIDNEY DMG, LUNG DMG.
ALSO OVEREXPOS TO MATL HAS BEEN SUGGESTED AS CAUSE OF (SUPDAT)

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED
NIOSH/MSHA JOINTLY APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE
OF ENVIRON CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA RESP
UNDER SPECIFIED CNDTNS. (SEE YOUR SFTY EQUP SUPPLIER) (SUPDAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL OR LOC EXHAUST) VENT
TO MAINTAIN EXPOSURE BELOW TLV'S
Protective Gloves:POLYVINYL ALCOHOL/POLYETHYLENE RESIST.
Eye Protection:ANSI APPROVED SPLASH GOGGLES .
Other Protective Equipment:PVNT RPTD/PRLNGD SKIN CONT W/GB PROT
HANDCREAM, WEAR IMPERVIOUS CLTHG & CHEM RESISTANT BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING/USING REST ROOM, SMOKE
IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXPLO HAZ:OVEREXPOS TO DECOMP PROD MAY CAUSE HLTH HAZ. SYMP MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. OTHER PRECAUT:FOLLOWING EFTS IN
HUMANS:CARDIAC ABNORM, LIVER ABNORM, KIDNEY DMG, & LUNG DMG. RES P
PROT:ENGINEERING/ADMINISTRATIVE CONTROLS SHOULD BE IMPLEMENTED TO
REDUCE EXPOSURE.

HCC:F3
Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.4 (H*20=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NON SOLUBLE
Appearance and Odor:SOLVENT ODOR

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES.
Hazardous Decomposition Products:HAZ DECOMP MAY PRODUCE CARBON DIOXIDE
AND/OR CARBON MONOXIDE.

Waste Disposal Methods:RECYCLE LIQUIDS IF POSSIBLE, INCIN SOLIDS I/A/W
APPLICABLE REGS. AS A LAST RESORT NEUTRALIZE & LANDFILL I/A/W
LOCAL, STATE, AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.